Hickory Roof Pros provides professional flat & low-slope roofing in Hickory, NC for residential and commercial properties across Catawba County and the Unifour. Low-slope roofing in Hickory is mostly small and residential: carport roofs, sunroom additions, breezeways and the flat sections between a house and a garage. Those are exactly the planes that receive water from something taller, which is why they leak.
The first question on any of them is what shingles are doing there. We still find three-tab and laminate shingles laid on two and three in twelve additions all over this county, usually because the crew that built the addition was a shingle crew. Asphalt shingles are not a low-slope product. Under sustained flow from an upper roof they back up at every course and the roof becomes a series of small dams.
What belongs there instead is a membrane. On residential additions we generally specify a self-adhered modified bitumen system, torch-free, with a granulated cap sheet, because it tolerates foot traffic, patches easily and does not depend on a single seam weld done in a tight space. On larger or fully flat areas TPO or EPDM makes more sense, and we will say which and why in the estimate.
Drainage gets designed rather than assumed. We calculate the contributing area, including the upper roof feeding it, and size the outlet accordingly. Where an upper downspout currently discharges onto a low-slope section, it gets extended into the lower gutter or onto a splash pan, because a two-inch stream landing on the same square foot of membrane for twenty years will find its way through anything.
On ponding we are direct. A quarter-inch of standing water on a small residential addition forty-eight hours after rain is not an emergency, and tearing off a sound membrane to chase perfect drainage is rarely worth it. Tapered insulation or a cricket to move water off a low spot is worth it when the water sits against a wall or over a seam, and we will point at the specific spot rather than generalize.
Where we say do nothing: a sound modified bitumen roof over a carport with ten years of service left, where the owner has been quoted a full tear-off because the surface has weathered gray. Weathered gray is what the cap sheet is supposed to do. Clean the debris out of the drain, re-flash the two penetrations, and spend the rest of the money somewhere it matters.
Our licensed and insured team brings the right materials and equipment to every job — kickout diverters soldered rather than caulked at the wall termination, self-adhered membrane run across the full receiving plane, headwall flashing tucked behind the wall covering on a two-story elevation, three by four downspout outlets set at the low end of the lower run, a doubled starter band laid in the impact strip below an upper eave, 26-gauge painted W-valley metal beneath an open valley cut — and backs the work with a written workmanship warranty. We serve Hickory and nearby communities including Newton, Conover, Long View, St. Stephens.
What We Handle
Everything our flat & low-slope roofing in Hickory covers
One crew, one point of contact, and the full range of flat & low-slope roofing work in Hickory, NC. If it is on this list we do it in house rather than handing it to a subcontractor:
- flat roof repair Hickory NC
- low slope roofing Catawba County
- TPO roof installation Hickory NC
- EPDM rubber roof Hickory North Carolina
- modified bitumen roof Hickory
- flat roof replacement Hickory NC
- porch roof low slope Hickory
- ponding water flat roof
- flat roof leak repair Catawba County
- single ply membrane Hickory NC
- tapered insulation flat roof
- flat roofer near me Hickory
Not sure which one describes your situation? Describe it in plain words and we will sort it out — or browse the rest of our Hickory services.
Materials, equipment and how we do flat & low-slope roofing
The difference between flat & low-slope roofing that lasts and flat & low-slope roofing that gets redone in three years is almost always preparation and materials, not the finish you see on day one. We work with kickout diverters soldered rather than caulked at the wall termination, self-adhered membrane run across the full receiving plane, headwall flashing tucked behind the wall covering on a two-story elevation, three by four downspout outlets set at the low end of the lower run, spec them to the job instead of to the invoice, and write the material grades into the free estimate so you know exactly what you are buying.
Every Hickory job runs the same way: site walk and measurements, written scope and fixed price, protection of the surrounding area, then the work itself with a daily clean-up. Years of roofing work in Catawba County and the Unifour means we have already met whatever your property is going to throw at us — awkward access, older construction, an HOA with opinions.
Where we do flat & low-slope roofing outside Hickory
Hickory Roof Pros covers Hickory and the surrounding communities of Catawba County and the Unifour. Crews run out to the same nearby cities every week, so an out-of-town job does not mean an out-of-town price.
- Flat & Low-Slope Roofing in Newton, NC — Catawba County, population 13,148
- Flat & Low-Slope Roofing in Conover, NC — Catawba County, population 8,421
- Flat & Low-Slope Roofing in Long View, NC — Catawba County, population 5,088
- Flat & Low-Slope Roofing in St. Stephens, NC — Catawba County, population 8,852
- Flat & Low-Slope Roofing in Mountain View, NC — Catawba County, population 3,590
- Flat & Low-Slope Roofing in Claremont, NC — Catawba County, population 1,692
Start on the Hickory Roof Pros homepage for a free estimate, or call (844) 511-2320 and describe the job.
Why Hickory Chooses Hickory Roof Pros
- ✓We grade planes, not roofs. A stacked Hickory house gets a separate condition note for each slope, and you keep that sheet whether or not you hire us.
- ✓Receiving planes get a membrane across the full field rather than the customary three-foot eave strip, because the water landing there does not stop three feet up.
- ✓Kickout diverters go on every roof-to-wall termination we build. They cost very little and they are missing from most of the brick-veneer stock in this county.
- ✓We will quote a partial replacement when the lower roof is finished and the field is not, and we will tell you plainly what the color mismatch will look like.
The standards behind flat & low-slope roofing
Quality here is not a matter of opinion — it is written down. The flat & low-slope roofing work we do in Hickory follows published industry standards: NRCA publishes the Roofing Manual, the industry's reference for details and slope minimums, and Asphalt Roofing Manufacturers Association sets the shingle application and ventilation guidance the warranties reference. If a contractor cannot tell you which standard a detail comes from, that is worth asking about before you sign.
Every flat & low-slope roofing project in Hickory gets the same attention, whether it is a single room or a full commercial job. We show up on schedule, keep the site clean, and stand behind the work — the estimate is free and there is no pressure.
Ready to get started? Call (844) 511-2320 for a free flat & low-slope roofing free estimate in Hickory, or request a quote and we'll get right back to you.